Product ID:PR-1136, PART A, ALL COLORS
MSDS Date:04/20/1989
FSC:8010
NIIN:00N048953
MSDS Number: BVNTN

PRODUCTS RESEARCH AND CHEMICAL CORPORATION

5430 SAN FERNANDO ROAD
GLENDALE, CA 91209
US

Emergency Phone: 800-228-5635;800-424-9300(CHEMTREC)

Info Phone: 818-240-2060

Cage: DO563

PRODUCTS RESEARCH & CHEMICAL

1800 GLENDALE, CA 91209 US

Telephone: 818-240-2060

Cage: DO563

ISOCYANIC ACID, METHYL-M-PHENYLENE ESTER;

CAS: 26471-62-5

RTECS: NQ9490000

OSHA PEL N/K

ACGIH TLV: 100 PPM

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 30%

OSHA PEL N/K

ACGIH TLV: N/K

POLYETHER POLYOL POLYMER WITH TOLUENE DIISOCYANATE

CAS: 9057-91-4

Fraction By Weight: 40%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:IRRIT, WATERING AND POSSIBLE
REVERSIBLE CORNEAL DAMAGE. SKIN:LOCAL IRRIT & DISCOLORATION. MAY
CAUSE AN ALLERGIC RASH IN SENSITIZED INDIVIDUALS. INHAL: IRRIT OF
NOSE, THROAT, LUNGS AND EYES, WITH WATERING EYES, SORENESS IN
THROAT, AND TIGHTNESS IN CHEST W/POSS DIFFICULTY IN BFEATHING. MAY
PRODUCE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARD: ASTHMA-LIKE SYMPTOMS IN
SENSITIZED INDIVIDUALS. INDIVIDUALS SUFFERING FROM ASTHMA OR OTHER
CHRONIC RESPIRATORY CONDITIONS MAY EXHIBIT A HEIGHTENED SENSITIVITY
TO ISOCYANATES AND SHOULD AVOID INHALATION EXPOSURE. INGEST: IRRIT
AND POSSIBLE CORROSIVE ACTION IN MOUTH, STOMACH TISSUE AND
DIGESTIVE TREACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: FLUSH WITH LUKE WARM WATER FOR AT LEAST 15 MINUTES.
CONSULT PHYSICIAN. SKIN: WASH THOROUGHLY WITH SOAP AND WATER.
CONSULT A PHYS. DISCARD OR DECONTAMINATE CONTAMINATED CLOTHING &
SHOES BEFORE RE USE. INHALATION: REMOVE TO FRESH AIR, IF NOT BRTHG
GIVE ARTF RESP. IF BRTHG IS DIFFICULT GIVE OXYGEN. CONSULT A PHYS.
INGEST: DO NOT INDUCE VOMITING. GIVE MIKE OR WATER TO DRINK.
CONSULT A PHYSICIAN.

Flash Point Method:PMCC
Flash Point:118F,48C
Lower Limits:1.5%
Upper Limits:SUPDAT
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR. USE WATER TO COOL HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINERS.

Spill Release Procedures:WEAR AIR-SUPPLIED RESP FOR MAJOR UNVENTILATED
SPILLS. COVER W/ABSORBENT MATL, ADD DECONTAMINATION SOLN (5%
CONCENTRATED AMMONIA, 2% DETERGENT, 93% WATER) & ALLOW TO REACT FOR
10 MINS. COLLECT IN CNTNR S, ADD ADDN DECONTAMINATION SOLN &
KEEP(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID MOISTURE CONTAMINATION WHICH
WILL CAUSE CO*2 PRESSURE. DO NOT RESEAL CONTAINERS IF MOISTURE
CONTAMINATION IS SUSPECTED. AVOID INGESTION.
Other Precautions:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR CHEMICALS
SUBJECT TO REPORTING REQUIREMENT OF SECTION 313 OF TITLE III OF
SUPERFUND AMENDMENTS & REAUTHORIZATION ACT OF 1986 AND 40 CFR PART
372.

Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS BELOW TLV.
Protective Gloves:SOLVENT-RESISTANT GLOVES.
Eye Protection:ANSI APPROVED GOGGLES AND FULL (SUP DAT)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VAPOR DENSITY: 4.6 (PM ACETATE). UEL: 7.0% (PM ACETATE). SPILL
PROCEDURE: LOOSELY COVERED FOR 48 HOURS. EYE PROTECTION: LENGTH
FACESHIELD .

HCC:F4
Vapor Density:SUPDAT
Spec Gravity:1.13
Evaporation Rate & Reference:0.4 (PM ACETATE)
Solubility in Water:APPRECIABLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.

Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, STRONG BASES, AMINES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN AND
POSSIBLE TRACES OF HCN.

Waste Disposal Methods:0001 EPA HAZARDOUS WASTE. DISPOSE OF IN
COMPLIANCE WITH STATE, FEDERAL AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.